The Misfire monitor diagnostic is based on crankshaft rotation velocity variation. The PCM determines crankshaft rotational velocity using the crankshaft position sensor and camshaft position sensor. When a cylinder misfires the crankshaft slows down momentarily. By monitoring the crankshaft and camshaft position sensor signals, the PCM can calculate when a misfire occurs. For a non-catalyst damaging misfire, the diagnostic will be required to report a misfire present within 1000-3200 engine revolutions. For catalyst damaging misfire, the diagnostic will respond to monitor 200 engine revolutions. Rough roads may cause false misfire detection. The rough road(acceleration)sensor consists of a piezoelectric vibration pick up which detects vertical acceleration of the vehicle. The sensor signal is used by the PCM to determine the degree of vertical movement of the car, for example, on a bumpy road. Since this may also cause uneven engine running, the PCM uses the signal to distinguish the phenomenon from actual misfiring.
The PCM must monitor the engine for misfiring possibly caused by ignition coil defects or injector fails. If misfiring is detected, the PCM will identify the cylinder(s) that has(have) misfired and then calculate misfiring rate for a given duration. The DTC for Misfire (P0301 to 0304) is set as soon as the misfiring rate exceeds the limit which may result in damage to the catalyst or increase emissions. The PCM stores the individual DTC for a cylinder which has more than a 10% total misfire rate.
Item | Detecting Condition | Possible Cause |
DTC Strategy | ● Calculation of engine roughness | ● Faulty spark plugs, high-tension lead, or Ignition coil. ● Incorrect valve timing. ● Uneven compression. ● Air leakage. ● Improper Fuel pressure or dirty fuel. ● Blocked/Leaking injectors. ● Leakage between cooling system and cylinder. |
Enable Conditions | ● 150＜ Mass air flow(mg/rev.)＜ 710 ● 512＜ Engine speed(RPM)＜ 6500 ● Coolant temperature＞20°C if Start temperature＜-7°C ● 11V< Battery voltage＜ 16V ● Throttle Angle gradient is in predetermined range ● No injector shut off ● No rough road | |
Case1) | Threshold Value Diagnosis Time | ● Misfire= 12~54% within 200 rev. |
● 200 revolution or 3*200 revolution. | ||
Case2) | Threshold Value Diagnosis Time | ● Misfire ＞1.2% within 1000 revolutions. |
● 1000 revolution or 4*1000 revolution |
Temp.(℃) | Temp.(℉) | Ignition primary coil (Ω) | Ignition secondary coil (㏀) |
-20 | -4 | 0.5 | 7.7 |
0 | 32 | 0.54 | 8.4 |
20 | 68 | 0.58 | 9.1 |
40 | 104 | 0.62 | 9.8 |
60 | 140 | 0.66 | 10.5 |
80 | 176 | 0.71 | 11.2 |
100 | 212 | 0.75 | 11.9 |
