5.
If the resistance is out of specification, or fails to change smoothly, replace the throttle position sensor.
Tightening torque
Throttle position sensor :
1.5 ~ 2.5 Nm (15 ~ 25 kg·cm, 1.1 ~ 1.8 lb·ft)
The TP Sensor is a rotating type variable resistor that rotates with the throttle body's throttle shaft to sense the throttle valve angle. As the throttle shaft rotates, the throttle angle of the TP Sensor changes and the ECM detects the throttle valve opening based on the TPS output voltage.
The TPS signal is important for the control of an automatic transaxles. Shift shock and other trouble may occur if the sensor is faulty.
If the idle condition or acceleration is abnormal, check the TPS connector. (When the TPS connector is not connected properly, the current data on HI-SCAN can show that the idle state remains off, although the accelerater pedal is released. This results in the improper idle or acceleration.)
Input voltage from throttle position sensor is below 0.1V or above 4.7V when ignition switch is turned on.
Check item | Data display | Check condition | Test specification |
Throttle position sensor | Throttle angle | At idle rpm | 5° ~ 16° |
Gradually open | Increases | ||
Wide open throttle | 80° ~ 98° |
Check item | Check condition | Test specification |
Throttle position sensor output voltage (TP Sensor side connector No.1 or ECM harness side connector No.16) | At idle rpm | 0.25 ~ 0.8V |
Wide open throttle | 4.0 ~ 4.8V |
Disconnect the throttle position sensor connector.
Measure the resistance between terminals 2 (sensor ground) and terminal 3 (sensor power).
0.7 ~ 3.0 kΩ
Connect an analog ohmmeter between terminals 2 (sensor ground) and terminal 1 (sensor output).
Operate the throttle valve slowly from the idle position to the full open position, and check that the resistance changes smoothly in proportion with the throttle valve opening angle.
If the resistance is out of specification, or fails to change smoothly, replace the throttle position sensor.
Tightening torque
Throttle position sensor :
1.5 ~ 2.5 Nm (15 ~ 25 kg·cm, 1.1 ~ 1.8 lb·ft)
