Symptom | Suspect Area | Remedy (See page) |
Water leaks from sunroof | Dirt accumulated in drain tube | Clear dirt inside of drain |
Clogged drain tube | Blow air into drain to remove dirt | |
Broken or dislocated drain tube, defective Or cracked clip | Check tube installation and Flange contact | |
Deteriorated roof lid weatherstrip | Replace | |
Excessive roof lid-to-body clearance and Improperly fitted weatherstrip | Adjust | |
Wind noise around sunroof | Loose or deformed deflector, gaps In body work | Retighten adjust or replace |
Sunroof lid makes a noise When move | Foreign particles lodged in guide rail | Check drive cable and guide Rails for foreign particles |
Loose guide rails and lid | Retighten | |
Motor runs but sunroof Does not move or moves only partially | Foreign particles lodged in guide rail | Check drive cable and guide Rails for foreign particles |
Incorrect engagement of motor pinion With drive cable | Check for loose motor installation And damaged pinion | |
Decrease in motor`s clutch slipping force | Adjust | |
Increased sunroof sliding resistance Or interference of sunroof with drive Cables, weatherstrip, etc. due to Maladjustment of sunroof | Adjust or replace | |
Noise in motor (clutch slipping Noise from motor when sunroof Is fully opened or closed is not An unusual noise | Incorrect engagement of motor pinion With drive cable | Check pinion installation and Retighten motor |
Worn out or damaged motor pinion bearing | Replace motor assembly | |
Worn out or deformed drive cable | Replace | |
Door glass fails to operate Up and down | Incorrect window glass installation | Adjust position |
Damaged or faulty regulator arm or regulator | Correct or replace | |
Door does not open or close completely | Incorrect door installation | Adjust position |
Defective door check assembly | Correct or replace | |
Door hinge requires grease | Apply grease | |
Hood does not open or close completely | Striker and latch not properly aligned | Adjust |
Incorrectly installed hood | Adjust | |
Incorrect hood bumper height | Adjust | |
Water leak through windshield end rear window | Defective seal | Fill with sealant |
Defective flange | Correct |
